Acta Univ. Agric. Silvic. Mendelianae Brun. 2010, 58(1), 43-52 | DOI: 10.11118/actaun201058010043
VLIV HUŠTĚNÍ PNEUMATIK NA PASIVNÍ ZTRÁTY TRAKTORU
- Ústav techniky a automobilové dopravy, Mendelova zemědělská a lesnická univerzita v Brně, Zemědělská 1, 613 00 Brno, Česká republika
Cílem realizovaného měření bylo stanovit vztah mezi tlakem huštění pneumatiky a velikostí pasivních ztrát traktoru, resp. soupravy traktoru a návěsu. Laboratorní měření proběhlo výzkumem změny valivého odporu na válcovém dynamometru na vozidlové zkušebně MZLU v Brně. V druhé experimentální části výzkumu proběhlo měření na silničním povrchu během rovnoměrného pohybu. Data byla zpracována v tabulkovém editoru MS Excel a statisticky vyhodnocena. Výsledky jsou interpretovány v grafické podobě závislostí síly pasivních ztrát, resp. výkonu na rychlosti pohybu. Výsledky přední nápravy traktoru JD 8530 ukazují, že v rozmezí rychlostí 0 až 16 km . h-1 se odpor valením mění pouze nepatrně, což dokládá nízká hodnota variačního koeficientu (3,51%). V tomto rozsahu rychlostí lze odpor valení považovat za konstantní. Měření traktorové soupravy John Deere 7810 s návěsem Annaburger HTS 20 B 79 v reálných silničních podmínkách přineslo závěrem rozdíl v měrné spotřebě paliva 10g.kW-1.h-1 ve prospěch vyššího tlaku huštění (270 kPa) při rychlosti 35 km . h-1.
pasivní ztráty, valivý odpor, vnitřní odpor valení, traktor
Influence of tire inflation on passive resistance of a tractor
The paper deals with influence of inflation pressure on passive resistance of a tractor and tractor's set. The parameter of inflation pressure is significant part of passive loss and its size can influence the need for engine power in units of kilowatts. This implies increase in fuel consumption up to several liters per hour. According to demands of methodology field and laboratory measurements have been done. It was used flat section of a road for field testing. Realization of the road test is based on pulling of tested tractor or tractor's set where the needed force is monitored. In this case overall passive resistance of both axles is done. The separation of forces applied in tire and its impact on inner or outer effect is described. The road test was based on the assumption that unlike the driven wheel the driving wheel did not affect inner component of resistance. The change in inflation pressure of driving tire has an impact on magnitude of hysteresis loss. Laboratory measurement was realized on chassis dynamometer which drives enable rolling resistance measuring in the range of 1 kph to 16 kph. Testing was focused on differences in overall size of passive losses when inflation pressure of front axle of a tractor was changed. The comparison of tire inflation of a semi-trailer has been done. Experimental work brought the results of coefficient of rolling resistance or its change as the physical description of tire deformation.
Keywords: passive losses, rolling resistance, inner drag of rolling, tractor
Grants and funding:
Příspěvek vznikl s podporou projektu COST 356 OC191 "Doprava v zemědělství a její dopad na životní prostředí" uděleného MŠMT ČR a Výzkumného záměru č. MSM6215648905 "Biologické a technologické aspekty udržitelnosti řízených ekosystémů a jejich adaptace na změnu klimatu" uděleného MŠMT ČR.
Received: October 5, 2009; Published: October 5, 2014 Show citation
References
- GREČENKO, A., 1994: Vlastnosti terénních vozidel. 1. vyd. Praha VŠZ, 118 s.
- GREČENKO, A., 1963: Kolové a pásové traktory. 1. vyd. Praha SZN, 402 s.
- Dočkal, V., Kovanda, J., Hrubec, F., 1998: Pneumatiky. 1. vyd. Praha ČVUT, 71 s.
- MARCÍN, J., ZÍTEK, P., 1985: Pneumatiky. 1. vyd. Praha SNTL, 491 s.
- Syrový, O., Gerndtová, I., 2005: Jak uspořit v dopravě? 1. vyd. Praha VUZT, 7 s.
- Calek, M., Schwanghart, H., 1998: Effect of tyre pressure on propelling forces and rolling resistence forces. Acta technologica agriculturae, Slovana Universita Agriculturae Nitra, 25, 40-44.
- Komandi, G., 1999: An evaluation of the concept of rolling resistence. Journal of Terramechanics 36, 159-166. DOI: 10.1016/S0022-4898(99)00005-1
Go to original source...
This is an open access article distributed under the terms of the Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License (CC BY NC ND 4.0), which permits non-comercial use, distribution, and reproduction in any medium, provided the original publication is properly cited. No use, distribution or reproduction is permitted which does not comply with these terms.